Study on Compressive Strength of Quarry Dust as Fine

(c) The compressive strength results of quarry dust concrete (cubes) were obtained in the third series, where M20, M25, and M30 grades of concrete with 20, 25, and 30 percent replacement of quarry dust and also workability are studied by varying the water-cement ratio

Mortar And Quarry Dust Compressive Strength

59 Substitution Of Quarry Dust To Sand For. 2011915table 3 comparison of compressive strength with group a bricks v cost analysis the cost of stone masonry and random rubble masonry in cement mortar 16 has been analysed with the average rates of materials in coimbatore district in appukutty et...

STRENGTH AND DURABILITY STUDIES ON CONCRETE USING

2016-04-23· STRENGTH AND DURABILITY STUDIES ON CONCRETE USING QUARRY DUST AS FINE AGGREGATE Dr.A.Vijayakumar1, K.Revathi2, preparation of cement mortar resulted in lowering of water table, soil erosion etc., in this study, compressive strength of concrete for 7 days, 14 days and 28 days and type of mix made with quarry dust. From the

Aging and Curing Temperature Effects on Compressive

Aging and Curing Temperature Effects on Compressive Strength of Mortar Containing Lime Stone Quarry Dust and Industrial Granite Sludge Article (PDF Available) in Materials 10(6):642 · June 2017

(PDF) Study on Compressive Strength of Quarry Dust as

Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete Article (PDF Available) in Advances in Civil Engineering 2016(3):1-5 · June

Strength Properties of Concrete with Partial Replacement of

2019-07-01· compressive strength, splitting tensile strength and flexural strength on specimens. Results showed that up to 7.5 % replacement of cement by quarry dust there was no reduction in compressive strength, splitting tensile strength and flexural strength. The experimental work was carried out with M sand confirming

Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine

Abstract. This stone presents the results of an experimental investigation carried out to evaluate the compressive strength and transverse strength of 1 : 3 mortar mixes in which natural sand was replaced with 20%, 50%, and 100% quarry dust by weight which were further modified by partially replacing cement with four percentages (15%, 20%, 25%, and 30%) of low calcium fly ash.

Research Article Study on Compressive Strength of Quarry Dust as

2019-07-30· Research Article Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete K.ShyamPrakash 1 andCh.HanumanthaRao 2 Department of Civil Engineering, PVP Siddhartha Institute of Technology, Kanuru, Vijayawada, Andhra Pradesh, India Department of Civil Engineering, K L University, Vijayawada,India

An Experimental study on compressive strength of Quarry Dust as

2017-11-08· quarry dust can be used as a replacement for fine aggregate. It is found that 50% replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases after replacement of fine aggregate. . Key Words: fine aggregate, quarry dust, compressive strength, replacement. 1. INTRODUCTION

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-05· to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.

Research Article Study on Compressive Strength of Quarry Dust

2019-07-30· Research Article Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete K.ShyamPrakash 1 andCh.HanumanthaRao 2 Department of Civil Engineering, PVP Siddhartha Institute of Technology, Kanuru, Vijayawada, Andhra Pradesh, India Department of Civil Engineering, K L University, Vijayawada,India

Compressive Strength of Fly Ash stone with Addition of Lime, Gypsum and Quarry Dust

2015-01-03· Compressive Strength of Fly Ash stone with Addition of Lime, Gypsum and Quarry Dust A. Sumathi*1, K. Saravana Raja Mohan2 1School of Civil Engineering,SASTRA University, Thanjavur, India 2Ramco Cements Chair Professor, School of Civil

Effects of Limestone Quarry Dust Content on Rheology

SCM mixtures were prepared using crushed limestone sand partially replaced with limestone dust at varying percentages (0, 5, 10, 15, 20, 25 and 30%). Tests used to characterize the properties of mortars include: slump flow, flow time, viscosity measurements, compressive strength and flexural strength at 3 and 28 days of age.

The Utilization of Quarry Dust as Fine Aggregates in Concrete

concluded that the compressive strength of concrete, with 50% Sand and 50% quarry dust (Mix 3), under thermo shock and high temperature showed the least reduction in strength. It was finally concluded that quarry dust can be effectively used for 50% replacement of sand in the conventional concrete. Utilization of Quarry Dust as Fine Aggregates

Influence of fineness of volcanic ash and its blends with

In this study researchers investigated the influence of fineness of locally available basaltic volcanic ash (VA) and its blend with other potential supplementary cementitious materials (SCMs) on compressive strength of mortar. Local quarry sites and steel making industries in the eastern province of Saudi Arabia produces tons of wastes commonly known as quarry dust (QD) and electric arc

Aging and Curing Temperature Effects on Compressive

2017-06-11· Aging and Curing Temperature Effects on Compressive Strength of Mortar Containing Lime Stone Quarry Dust and Industrial Granite Sludge. Amin MN(1), Khan K(2), Saleem MU(3), Khurram N(4), Niazi MUK(5).

Water Absorption and Compressive Strength of Self-Compacting

2018-10-13· Ahmad,[1] conducted experimental study to replace sand with quarry dust with the proportion of 10, 20, 30 and 40% and super plasticizer was added 0.9%. Study found that workability and compressive strength has increased by 30% replacement of sand with quarry dust and further addition leads to the decrease the compressive strength and workability.

USE OF DUNE SAND AS AN ALTERNATIVE FINE AGGREGATE IN CONCRETE AND MORTAR

2017-08-08· Quarry dust % in mix X(mm) Flow value(mm) 1 100 0 230 200 215 4 70 30 150 150 150 6 50 50 140 140 140 8 30 70 125 143 134 10 10 90 120 120 120 Hardened state Compressive strength of mortar Figure 1b shows the compressive strength results of

Experimental Investigation on Performance of Fly ash and Quarry Dust

2019-07-01· Experimental Investigation on Performance of Fly ash and Quarry Dust in a Concrete Indumathy V Department of Civil Engineering, Anna University, Chennai. Abstract- This stone presents the results of an experimental investigation carried out to evaluate the compressive strength and transverse strength of 1:3

Compressive Strength by Incorporating Quarry Dust in

Slump flow, J- Ring tests were carried out to determine the workability of self-compacting concrete and compressive strength test was conducted on 7 days and 28 th days of curing period. A finding of the study shows that workability and compressive strength has increased by addition of quarry dust.

Characteristic studies on the mechanical properties of quarry dust

2015-09-09· Effect of quarry dust on compressive strength of concrete The 100 mm size concrete cubes were used as test specimens to determine the compressive strength. The test results of the cubes are compiled in Figures 2 to 7. 59. The compressive strength of concrete cube (100% replacement of sand with quarry dust) and natural sand

Use of Quarry Dust to Replace Sand in Concrete An

2017-03-30· clear picture that quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is

Investigating Strength Properties of Geopolymer Concrete

The results indicated that geopolymer concrete achieved comparably equal strength to that of the reference concrete mixture at a 100% quarry dust level. External exposure and ambient curing can be practiced to attain comparable strength properties of geopolymer concrete with quarry dust

IOP Conference Series: Materials Science and Engineering stone

quarry dust tested for 3 days, 7 days and 28 days is identified and presented the results. Figure 5: Compressive strength of M30 with 20%, 25% and 30% replacement for 3, 7 and 28 days The slight variation is observed in compressive strength for 3 days and 7 days age in concrete. The compressive strength of M30 concrete has been tested for 3, 7

The strength and durability of fly ash and quarry dust

This research stone produce the compressive strength, split tensile strength and durability properties such as water absorption and permeability. From the investigation it have been concluded that the replacing partially 30% of fine sand b and quarry dust combination produced better quality results in par with the conventional foam concrete.

Aging and Curing Temperature Effects on Compressive

Aging and Curing Temperature Effects on Compressive Strength of Mortar Containing Lime Stone Quarry Dust and Industrial Granite Sludge. Muhammad Nasir Amin Department of Civil and Environmental Engineering, College of Engineering, King Faisal University (KFU), P.O. Box 380, Al-Hofuf, Al-Ahsa 31982, Saudi Arabia.

COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC SAND AND QUARRY DUST

2012-02-08· COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC SAND AND QUARRY DUST AS FINE AGGREGATE Joseph O. Ukpata1, Maurice E. Ephraim2 and Godwin A. Akeke1 1Department of Civil Engineering, Cross River University of Technology, Calabar, Nigeria 2Department of Civil Engineering, Rivers State University of Science and Technology, Port Harcourt, Nigeria

Mortar Using Quarry Dust

mortar mix using quarry dust and results are very surprisingly. Compressive strength of quarry dust concrete Use of quarry dust in concrete help in workability of concrete. 6. Quarry dust is a waste product from stone crushing industry and available almost free-of-cost, as partial. An Experimental study on compressive strength of Quarry

Strength Studies on Metakaolin Modified Cement Mortar

This stone presents the results of a study to use metakaolin in cement mortar as a partial replacement of cement where quarry dust was used as the fine aggregate. The effect of water binder ratio and metakaolin replacement level on the compressive strength of cement quarry dust mortar

QUARRY DUST FINE POWDER AS SUBSTITUTE FOR ORDINARY

2014-02-25· Quarry Dust Fine Powder as Substitute for Ordinary Portland Cement in Concrete Mix 193 Journal of Engineering Science and Technology April 2014, Vol. 9(2) enhances compressive strength at hardened state [3]. However, there is still limited

Ready Mixed Plastering Mortar Pack Incorporating Quarry Dust

2016-10-11· and quarry dust mortar prism results were presented in Table 3. Table 3. Flexural and compressive strengths of river sand and quarry dust mortar prisms e e strength 4 2 Fig. 2 and 3 represent the 7 days and 28 days flex-ural strength of river sand and quarry dust mortar with w/c ratio, respectively. 5 4.5 mm 0

Determination of mortar strength using stone dust as a

Determination of mortar strength using stone dust as a partially replaced material for cement and sand mortar;cement;sand;compressive strength;tensile strength;stone dust;replacement; Mortar is a masonry product which is matrix of concrete. It consists of binder and fine aggregate and moreover, it is an essential associate in any reinforced structural construction.

EXPERIMENTAL STUDY ON STRENGTH OF CONCRETE BY PARTIAL

2017-09-23· Concrete mixes were tested for compressive strength and split tensile strength of concrete replaced by quarry dust was compared. The aim of the test was to find the mix proportion which shows strength values are high compared to natural concrete. Key words: Quarry dust, Compressive strength, Split tensile strength, Environmental Pollution.

Influence of Marble Powder Mortar and Concrete Mix

2020-04-21· 28 days Compressive Strength Test on Mortar Test results tor every specimen were shown below in Table 4. Hameed M S and Sekar A S S (2009) Properties of Green Concrete containing Quarry Rock Dust and

Compressive Strength of Mortar -Mix Ratio and Cube Test

2020-05-02· Determination of Compressive Strength of Mortar. To find the compressive strength of standard cement sand mortar cubes, following are the apparatus and procedures of the test. Apparatus. 7.06cm cubes moulds (50cm 2 face area), apparatus for gauging and mixing mortar, vibrator, compression testing machine etc. Procedure for Compressive Strength

Study on Strength of Innovative Mortar Synthesis with Epoxy Resin, Fly Ash and Quarry Dust

2016-05-30· quarry dust and fly ash in order to moderate the cost of mortar. The main objective of this work is to study the compressive strength of mortar cubes by various combinations of cement and fine aggregate replaced by Epoxy resin, fly ash, and quarry dust at the age of 7 days. The results of mortarmade with cement replaced with 20%,

EXPERIMENTAL STUDY ON REPLACEMENT OF FINE AGGREGATE BY QUARRY DUST

2015-04-21· work is an attempt to use Quarry Dust as replacement for Sand. Attempts have been made to study the basic properties of Quarry dust and compressive strength of Quarry dust concrete. The quarry dust behaves similar to conventional fine aggregate (sand) with

Strength of Quarry Dust Modular Bricks and Wallettes

Abstract. The compressive strength of masonry can be verified using two methods namely the unit strength method and the prism test method. The characteristics of masonry are influenced by the properties of bricks and mortar. This stone reports the investigation made on the compressive strength of bricks manufactured using quarry dust as sand replacement.

STUDY OF OPTIMUM COMPRESSIVE STRENGTH OF stone KERNEL SHELL QUARRY DUST

2019-07-10· with palm-kernel shells at 100% quarry dust were examined. Results show that compressive strength decreased with increase in proportions of palm-kernel shell. For 100, 50, and 0% stone kernel shells in the concrete containing 100% quarry dust, the compressive strength at 28 days were 15.06 N/mm 2, 17.72 N/mm,and 35 N/mm2

Strength and Corrosion Resistance Properties of Ggbs Concrete Containing Quarry Dust

2015-09-22· Strength and Corrosion Resistance Properties of Ggbs Concrete Containing Quarry Dust as Fine Aggregate . A. Krishnamoorthy and R. Aswini . Department of Civil Engineering, Adhiparasakthi Engineering College, Melmaruvathur, India . Email: [email protected]; [email protected]